Opening Hours : Providing solution design within 24 hours

Call Now

0086-21-58385887

saw dust as fine aggregate in concrete

  • Home
  • saw dust as fine aggregate in concrete

A Study on Granite Saw Dust Fly Ash Blended Geopolymer ...

coarse aggregates, fine aggregates and water are also used in concrete construction. As the requirement for development ... drying shrinkage of concrete with granite saw dust were less than those of ordinary concrete specimens. 3. Experimental Investigation . A. Materials used

Get Price

EXPERIMENTAL STUDY ON PARTIAL REPLACEMENT OF FINE ...

Key Words: Cement, Sawdust, Quarry dust, Fine aggregate. 1. INTRODUCTION Concrete is that probable mix of cement, water, sand and coarse aggregate that hardens into a super strong building material. River sand used as fine aggregate in concrete is derived from river bank. River sand has been the most popular choice for the fine aggregate ...

Get Price

EXPERIMENTAL STUDY ON STRENGTH OF CONCRETE BY …

replacement for fine aggregate in dust is a byproduct of cutting drilling or otherwise resulting from the mecha nical this fine aggregate was replaced by saw

Get Price

A STUDY ON PROPERTIES OF CONCRETE WITH CERAMIC …

materials like Msand, quarry dust, saw dust, rice husk ash, ceramic waste etc in concrete. Ceramic waste may be used as an alternative for natural sand. The aim of ... • To replace fine aggregate in concrete by using ceramic waste in various proportions (0%, 25%, 50% and 75%)

Get Price

table of content for a project work on sawdust in partial ...

Saw Dust Ash as Partial Replacement for Cement in Concrete. SDA content increased indicating that concrete becomes less workable as the SDA .... In the long run, the use of SDA as partial ... SDA concrete. Sample. Mix proportions (kg/m3) w/b. Cement. Sawdust ash. Fine aggregate ...

Get Price

Low Cost Construction Material for Concrete as Sawdust

The unit density of the concrete block is tested also. Research paper has proved that saw dust Concrete can be used as a Structural Concrete at suitable replacement percentage .and also affects the cost of the construction. ... 20% fine aggregate replaced by saw dust by volume each.

Get Price

EXPERIMENTAL STUDY ON PROPERTIES OF CONCRETE BY …

natural fine aggregate resources. There is however some obstacles for the use of sawdust ash aggregate in concrete. Codes limitations on water absorption and lack of knowledge about the behavior of concrete made of sawdust ash as fine aggregate. The first use of sawdust and shavings in place of sand and gravel to get a lighter and cheaper concrete.

Get Price

saw dust as fine aggregates « BINQ Mining

Investigations on sawdust and palm kernel shells as aggregate …. This study investigated the use of saw dust and palm kernel shells (PKS) as replacement for fine and coarse aggregates in reinforced concrete slabs. Reinforced … »More detailed

Get Price

REPLACEMENT OF FINE AGGREGATE WITH SAWDUST

REPLACEMENT OF FINE AGGREGATE WITH SAWDUST. ... “Saw dust ash as partial replacement of cement ... An experimental investigation on copper slag as replacement of fine aggregate in concrete.

Get Price

Saw Dust As Fine Aggregate In Concrete

Saw Dust As Fine Aggregate In Concrete. Effect on Strength Properties of M30 Grade of . varying proportion in the concrete .The replacement of fine aggregate (sand) . concrete. SAW DUST Wooden saw dust obtained from wood cutting. Get Price And Support Online; literature review on replacement of fine aggregate by .

Get Price

REPLACEMENT OF FINE AGGREGATE WITH SAWDUST

the fine aggregate. It is also used to analyze the effect of sawdust concrete in terms of workability, adhesion of aggregates and etc. After preparing the concrete block, the difference in weight between the original concrete and the sawdust concrete block is also tested. The sawdust is mixed in definite proportions with the concrete.

Get Price

EXPERIMENTAL STUDY ON CONCRETE IN PARTIALLY …

flexural of the conventional concrete and the saw dust concrete and to find the saw dust content required to attain maximum compressive strength. Adding saw dust to the mix by partially replacing fine aggregate to cast concrete specimens. The saw dust have to add by 10, 20 30

Get Price

Use of Saw Dust as Fine Aggregate in Concrete Mixture

Key Words: Compressive strength, Concrete, Sawdust, Light weight concrete, Fine Aggregate. 1. INTRODUCTION Concrete is a mixture of cement, fine and coarse aggregates and water, which are mixed in a specific proportion to get a particular strength. Both cement and water react together chemically to form a paste, which binds the aggregate

Get Price

saw dust in concrete BINQ Mining

saw dust in concrete. Posted at:June 13, 2013[ 3627 Ratings] ... Saw Dust Ash as Partial Replacement for Cement in Concrete. chemical composition of saw dust ash (SDA) as well as the workability, ... composed by replacing fine aggregates by sawdust at 5% weight.

Get Price

Saw Dust As An Alternative To Fine Aggregate In Concrete

Concrete is a composite material composed of coarse granular material (the Concrete is a mass of sand, gravel, crushed rock, or other aggregate bonded saw dust ash or rice husk ash mixed with bone ash as partial replacement for

Get Price

Partial Replacement of Cement by Saw Dust Ash in Concrete ...

Partial Replacement of Cement by Saw Dust Ash in Concrete A ... saw dust ash as partial replacement of cement in concrete. Cement was replaced by Saw Dust Ash as 5%, 10%, ... River sand has been the most popular choice for the fine aggregate component of concrete in the past,

Get Price

ANALYSIS ON STRENGTH OF CONCRETE BY PARTIAL …

i. Sawdust The properties of saw dust are shown in Table3. It shows the density of light weight aggregate and will reduce the overall density of concrete. The thermal properties and fire resistance will be very less as sawdust used in the concrete. ii. Robosand Robosand or MSand was used as replacement of fine aggregate.

Get Price

ISSN No: 23484845 International Journal Magazine of ...

International Journal Magazine of Engineering, Technology, Management and Research ... in dust and robosand in proportion used as fine aggregates in concrete and the compressive and split tensile strength were tested. There were totally five mixes prepared for the investigation, gradually increasing the ...

Get Price

EXPERIMENTAL STUDY ON PARTIAL REPLACEMET OF FINE …

concrete fine aggregate is partially replaced by quarry dust and saw dust. The present investigation has been undertaken to study the effect of quarry dust and saw dust, by adding quarry dust of 10%, 20% and 30%, and saw dust of 10%, 15% and 20% with the fine aggregate, a matured fine aggregate has prepared.

Get Price

Saw Dust Ash as Partial Replacement for Cement in Concrete

compacting concrete containing sawdust ash. Elinwa and Mahmoodb (2002) considered ash from timber waste as cement replacement material. The pres ... for fine aggregates are and respectively. Thus, the sand can be said to be well graded (Smith and Smith, 1998). Similarly, the C u

Get Price

saw dust as fine aggregate in concrete

Effect of Sawdust as Fine Aggregate in Concrete Mixture for Building Construction. It was noted that, both the density and compressive strength of concrete decreased as the percentage replacement of fine aggregate by saw dust increased[29, 31]. However, ... Get A Free Quote

Get Price

Performance of Ground Granulated Blast Furnace Slag ...

saw dust in concrete making . In this study , Ground granulated blast furnace slag is used as coarse aggregates in place of conventional aggregates in concrete making and saw dust as partial substitute to conventional fine aggregates (sand). II. OBJECTIVE

Get Price

STRENGTH INDICES OF ALKALINE ACTIVATED LATERIZED …

The Saw Dust Ash (SDA) was 5% of the total binder content and Laterited as partial replacement of the fine aggregate at 25% of the total fine aggregate content. A total of 108 concrete cubes (150 X 150 x 150mm) and 108 concrete cylinders (150 x 300mm) were …

Get Price